Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
X
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
X
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
X
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
X
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
  
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
X
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
  
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes     No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
X
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   CHLORINE 50-100 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   WHITE GRAVY 132, MASHED POTATOES 117, CHILI 158, BROWN GRAVY 155, MAYO 38, CHEESE 41, FETA CHEESE 42, COLE SLAW 40, RIBS 42, HAM 41, CHEESE 42
 
General Comments
 
Report and Instructions Received By   LOIS B. MUSSA /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  09/30/2013 Time In  1:30 PM Time Out  3:15 PM Sanitation Score  78 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  87  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*3  Observed the following potentially hazardous foods to be held at improper temperatures. 1. White gravy was found at 132F. 2. Mashed potatoes was found at 117F. The internal temperature of potentially hazardous foods shall be 135°F, or above except during necessary periods of preparation, including foods requiring transportation. 750.150 Immediate/Onsite
*7  Observed eggs were stored above other food. Employee will store eggs on bottom shelf. 750.150 Immediate/Onsite
5  Observed no thermometer to be available in the following units. There is no visible thermometers in refrigerator or freezer. Provide for an accurate, conspicuous thermometer, that is accurate within +/- 3°F, to be available in all units holding potentially hazardous foods. 750.140 Next Inspection
8  Observed the following food products to be improperly stored. Boxes of food stored on floor in both dry storage area. Provide for all food products to be stored at least six inches off of the floor. 750.130 Next Inspection
9  Observed food service employees to be handling ready-to-eat foods without minimizing direct hand contact with the food product. Bowl found in rice & flour in dry storage area. Food employees shall avoid direct contact with ready-to-eat food whenever possible and, to the extent possible, shall handle ready-to-eat food only with suitable utensils such as a deli tissue, spatulas, tongs, or single-use gloves. 750.280 Next Inspection
14  Observed the following improper food contact surfaces. Cutting board has a lot of knife grooves in them. Provide for all food contact surfaces to be smooth, easily cleanable, non-absorbant, corrosive resistant, and light colored. 750.650 Next Inspection
22  Observed the following food contact surfaces to be unclean. Bottom of the reach-in cooler has a lot of water on it. 2. There is grease & debris on shelf where flour is stored located by stove. Clean and maintain. 750.800 Next Inspection
23  Observed the following contact surfaces to be unclean. 1. Under microwave there is debris on shelf. 2. Seal gaskets have food debris in them. 3. Interior of fryers has grease & food debris in them. 4. Bottom of True cooler has food debris on it. 5. Top part of refrigerator has food debris on shelf. Clean and maintain Next Inspection
33  Observed trash is full. Empty trash in the kitchen. 750.1150 Next Inspection
36  Observed the following floor areas to be unclean: Old card board found below handsink. 2. Floor behind stoves has grease & food debris on it. Floor in walk-in frezzer has food debris under shelves. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
     
     
     
     
     
     
     
     
Report and Instructions Received By   LOIS B. MUSSA /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  09/30/2013 Time In  1:30 PM Time Out  3:15 PM Sanitation Score  78 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  87  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
     
Report and Instructions Received By   LOIS B. MUSSA /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  09/30/2013 Time In  1:30 PM Time Out  3:15 PM Sanitation Score  78 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  87